V10 January 2014 BRITISH GLIDING ASSOCIATION SAFETY MANAGEMENT SYSTEM MANUAL 1 V10 January 2014 1. Amendment Procedures, Record of Amendment, Distribution and List of Contents 1.1 Amendment Procedures Amendments will be promulgated by the Accountable Manager in conjunction with the Safety Committee and will be published online as a complete revised document. All nominated post holders will be advised of published revisions. 1.2 Record of Amendment Issue Initial issue v10 Date 8th January 2014 Issue Date 1.3 Distribution List Promoted and available online at www.gliding.co.uk Forwarded in e-format to;  All Nominated Post Holders  All BGA Executive Committee 2 V10 January 2014 1.4 Contents Content 1. Amendment Procedures, Record of Amendment, Distribution and List of Contents 1.1 Amendment Procedures 1.2 Record of Amendment 1.3 Distribution List 1.4 Contents 2. Introduction 3. Safety Policy and Objectives 4. Safety Organisation 4.1 Safety Management System - Scope 4.2 Safety Management Accountabilities and Responsibilities 4.2.1 Nominated Post Holders 4.2.2 Nominated Post Holder Review 4.2.3 Safety Committee 4.3 Selection, Recruitment, Development and Training of People 4.4 Management Structure 5. Publications 5.1 Procedures and Guidance 5.2 BGA Publication Control 5.3 BGA Master Publications 6. Hazard Identification and Risk Management 6.1 Reporting 6.2 Safety Investigations and remedial Action 6.3 Club Safety Review 6.4 Hazard Identification and Risk Assessment 6.4.1 Hazard Identification Page No 2 2 2 2 3 5 6 7 7 7 7 8 8 9 9 10 10 10 10 11 11 11 11 11 12 3 V10 January 2014 6.4.2 Risk Assessment 6.5 Risk Management Process 7. Safety Assurance 7.1 Safety Assurance through Quality Management 7.2 Quality Management Process & Procedures 7.3 The Quality Management Process - Schematic 8. Change Management Process 8.1 Change Hazard and Risk Assessment 9. Emergency Response Planning 9.1 Emergency Response Plan 9.2 Guidance Material 10. Communication 10.1 Communication of Safety Concerns 10.2 Safety Education Communication Appendix 1 – Example Club Safety Review Appendix 2 – Club Incident Reporting Guidance 12 13 15 15 15 15 16 16 17 17 17 18 18 18 19 20 4 V10 January 2014 2. Introduction The British Gliding Association (BGA) consists of a central organisation and gliding clubs. This Safety Management System manual combines and documents BGA policy on the safety of aviation in gliders and associated operations. It does not provide a means of compliance with occupational health and safety or environmental legislation. The safety management system will monitor operational standards and procedures through a structured audit and reporting schedule to ensure compliance where required with BGA and legislative requirements. As a non-complex, non-commercial air sport activity, gliding within the BGA and its member clubs is regulated by the UK Air Navigation Order and applicable EASA regulations, and by the BGA’s own operational regulations and recommended practices. The overall responsibility for the BGA organisations policy guidelines in respect of the BGA Safety Management System rests with the BGA Executive Committee. The responsibility for implementing the Safety Management System is delegated to the Accountable Manager and the Nominated Post Holders, including those at clubs, who ensure that an integrated approach to all operating standards is achieved and that all necessary regulatory and legal requirements are satisfied. Proposed amendments may be initiated by any part of the BGA but must be submitted through the Accountable Manager, who is responsible for the amendment and production of the manual. Drafting of amendment proposals will be delegated to the relevant Nominated Post Holder. This publication will be reviewed annually by the Safety Committee. 5 V10 January 2014 3. Safety Policy & Objectives The British Gliding Association, which includes all member clubs, is committed to safe practices with the objective of facilitating a sport gliding environment where the levels of risk are as low as reasonably practicable. This will be achieved through the implementation of an effective Safety Management System and a process of continuous improvement. The Accountable Manager has the responsibility to provide adequate resources to ensure that the BGA organisation can support and assist clubs and members to comply with all applicable legislation and procedural requirements to satisfy this policy. The procedures necessary to achieve these aims are fundamental to this policy and apply to members, staff, and contractors. The BGA gives priority to continuing to reduce the fatal accident rate, to not harming any third parties and to avoiding any airspace infringements. The British Gliding Association has an open reporting culture that encourages free and frank reporting within a just culture. ‘Safety is everyone’s responsibility’. Signed: Chief Executive and Accountable Manager Signed: BGA Chairman 6 V10 January 2014 4. Safety Organisation 4.1 Safety Management System - Scope The BGA Safety Management System is designed to support safe operations by BGA clubs and members. Some risks potentially impact upon all members, visitors and other third parties, and need management by clubs and the BGA. These risks include those associated with airworthiness of aircraft, launching operations, and navigation to avoid controlled airspace. Gliding is first and foremost an air sport activity. The appetite for risk from flying gliders varies among the sports participants. This aspect of risk is managed at three levels: 1. Third party visitors. Through training and risk-averse operational policies the risk is eliminated as far as is practicable. 2. Flights by unqualified** pilots who are therefore not equipped to effectively manage the risk for themselves. These risks include those associated with flight training and solo supervision. 3. Flights by qualified participants who can control the risk for themselves based on knowledge, the available information and experience. **Qualified = holds either Bronze & Cross Country Endorsement or a recognised Glider Pilot Licence. 4.2 Safety Management Accountabilities and Responsibilities The responsibility for implementing the safety and quality systems is delegated to the Nominated Post Holders who ensure that an integrated approach to all operating standards is achieved and that all necessary regulatory and legal requirements are satisfied. 4.2.1 Nominated Post Holders The Safety Management System Nominated Post Holders are; Accountable Manager (Chief Executive Officer) The Chief Executive Officer as Accountable Manager has overall accountability for the management of safety and compliance and is responsible for;  The management organisation, ensuring that all operations, training and maintenance activity can be financed and carried out to a standard acceptable to the regulator  Ensuring that the Safety Management System is effective in identifying hazards and risks and that they are mitigated and documented  The promotion of safety and compliance within the BGA  Acting as the Safety Manager  The implementation and maintenance of the SMS 7 V10 January 2014 Nominated Post Holder – Club Chairman (supported as applicable by Club Officials including the Chief Flying Instructor) Clubs have responsibility through their club officials for the effective safe management of operations at their club sites. This includes ensuring that hazards and risk relating to their club sites are identified, reasonably mitigated & documented. Nominated Post Holder - Airworthiness (Chief Technical Officer) The Chief Technical Officer has responsibility for the effective safe management of BGA facilitated airworthiness activity. Nominated Post Holder - Flight Training (Training Standards Manager) The Training Standards Manager has responsibility for the effective safe management of BGA facilitated flight training activity 4.2.2 Nominated Post Holder Review Training and Airworthiness nominated post holders shall ensure that documented reviews of the safety management system within their areas of responsibility are carried out as detailed in the BGA ATO Manual and the BGA Airworthiness Exposition. Club Chairmen should ensure that a documented review of safety management at their club is carried out at least every 3 years. The aim of the documented review is to ensure the system remains fit for purpose. Examples of items to consider in a club safety review are at Appendix 1. 4.2.3 Safety Committee The Safety Committee reviews all key safety and quality issues, reports to the BGA Executive Committee and is chaired by the Accountable Manager who is supported by a secretary function. The Safety Committee should meet at least twice per year. The terms of reference for the Safety Committee are detailed in the BGA Committee Terms of Reference publication and summarised here as;  Review the SMS publications  Review significant incidents and findings  Review and maintain the hazard matrix  Ensure trends are monitored effectively  Commission where required and review progress of safety improvement activity  Ensure issues are effectively communicated  Monitor the effectiveness of the safety management system The Safety Committee consists of the;  Accountable Manager  Safety Data Analyst  Chief Technical Officer  Training Standards Manager  Regional Safety Officer co-ordinator  Chief Accident Investigator  Invited subject matter experts as required 8 V10 January 2014 4.3 Selection, Recruitment, Development and Training of People Nominated post holder posts that affect the safety of operations should be filled by people on the basis of knowledge, skills, training and experience appropriate to the role. Training needs must be considered at appropriate frequencies to ensure that performance levels remain high and, where required, complies with the relevant regulation. Those responsible for compliance management should have received training covering the following;  An introduction to the concept of Quality Management  Audit techniques  Reporting and recording 4.4 Management Structure The overall BGA governance responsibilities, including safety responsibilities, sit with the elected BGA Executive Committee. The BGA Executive Committee has an elected chairman. Club governance responsibilities, including safety responsibilities, sit with the relevant Club Committee. Each club has an elected or nominated chairman who is expected to appoint a club safety officer. Organisation responsibilities and management structure is defined within the Airworthiness Exposition or manual. The following diagram illustrates the management structure. BGA Chairman & Exec Committee Chief Accident Investigator Club Chairmen CEO/Accountable Manager Quality Manager(s) Club Safety Officer Training Standards Manager Training Organisation Post Holders Chief Technical Officer Safety Committee Airworthiness Organisation Post Holders Regional Safety Officer Co-ordinator A number of Regional Safety Officers 9 V10 January 2014 5. Publications 5.1 Procedures and Guidance The procedures and guidance that apply to BGA operations are a fundamental element of safety management. The Accountable Manager in consultation with the Executive Committee will determine what procedures and guidance should be made available in BGA publications. The publications will be made available to BGA clubs and their members. Some clubs may have in place local procedures published in club publications, for example a club flying order book. Club Chairmen, as Nominated Post Holders, will maintain such club publications as necessary. 5.2 BGA Publication Control BGA publications should be freely accessible to all who need them. This is normally facilitated by making the publications available online. Master publications should be adequately protected and backed-up. The Accountable Manager will maintain the Master publications. All amendments and any variations to procedures should be reviewed prior to incorporation and be approved by the Nominated Post Holder. If an amendment concerns any part of a CAA approval, the CAA must approve the amendment prior to it becoming effective. Changes must be communicated to users. All documents in the master document list should be identified with their revision status. An audit trail of source and revision history should be maintained. Manuals and procedures should be subject to regular review to retain the currency of the contained information. 5.3 BGA Master Publications Publication BGA Laws and Rules BGA SMS Manual BGA Airworthiness Exposition BGA ATO Manuals Local Site Hazards Appendix Responsible Post Holder Accountable Manager Accountable Manager Chief Technical Officer Compliance Manager Club Local Head of Training (refer to the ATO Manual) 10 V10 January 2014 6. Hazard Identification and Risk Management 6.1 Reporting BGA guidance on both the UK minimum legal requirement and BGA requirement for reporting accidents and serious incidents is described in BGA Laws and Rules. In the case of accidents on a gliding club site, the Club on the site (usually by delegation to the club CFI or Safety Officer) must ensure the necessary report has been submitted to the AAIB/BGA. In all other cases, the pilot in command involved in the accident must ensure reporting is undertaken. Incident and accidents reported to the BGA are recorded on the BGA incidents and accidents database. Clubs are to establish a club incident reporting system that proactively encourages reporting and includes a review and follow up process. Guidance is detailed at Appendix 2 6.2 Safety Investigations and remedial Action The purpose of an investigation of any accident or incident is to establish the facts and cause and thereby prevent further occurrence. The purpose is not to apportion blame or liability. The BGA has an Accident Investigation Team led by the Chief Accident Investigator, who reports to the Chairman of the BGA. The BGA Accident Investigation Team terms of reference are detailed in the BGA Committee Terms of Reference publication. Depending on the outcome of a reported incident or accident, the investigation will be conducted by either the relevant club Chief Flying Instructor or Safety Officer, or BGA Accident Investigator or the AAIB. In each case, the investigator shall determine as quickly as possible the facts of the incident in order to initiate any changes to procedures, operating or engineering standards, modifications of equipment or other measures. The BGA will cooperate fully with Investigators from appropriate State Authorities when a formal investigation is being carried out. The Chief Accident Investigator will be the primary point of contact with the State Investigators. 6.3 Club Safety Review Club safety reviews should be carried out by clubs every three years ideally with the participation of a BGA Regional Safety Officer. A copy of the report of the completed safety review should be sent to BGA HQ and maintained on file. Reports will be routinely reviewed by the Safety Committee to assist in identifying trends. 6.4 Hazard Identification and Risk Assessment Hazard analysis and risk assessment tools are important in providing a proactive approach to safety management. They will identify areas of relatively higher risk and will also aid the development of safe, effective, procedures and practices. 11 V10 January 2014 6.4.1 Hazard Identification Effective identification of hazards (potential to cause harm) is achieved by;  Review of accidents/incidents from internal/external sources  Identifying deficiencies during reviews  Identifying hazards that are possible but have never occurred  Periodical review of hazards if there are changes  Known hazards mitigated through published BGA operational requirements and guidance material Hazard identification is regularly conducted to provide a comprehensive assessment of the risks faced by the operation. Measures are put in place through the SMS process to mitigate the risks. 6.4.2 Risk Assessment Risk assessment is a subjective, qualitative method of evaluating and predicting the likelihood and severity of loss inherent in the identified hazard. A Risk Matrix as illustrated in the two examples below will be used to determine the Risk Tolerability and identify the level and scope of mitigation measures. Example Risk Matrix – Severity/Likelihood Values Aviation Definition Catastrophic Very Damaging Serious Of Concern Minor ILLUSTRATIVE SEVERITY OF OCCURRENCE Results in third party fatal or other accident with the potential to significantly damage gliding in the UK Fatal accident to a 3rd party on or near a gliding site Fatal or Serious injury accident Minor injury accident Nil injury accident or incident Value 5 4 3 2 1 Qualitative Definition Frequent Occasional Remote Improbable Extremely Improbable LIKELIHOOD OF OCCURRENCE Likely to occur many times Likely to occur sometimes Unlikely to occur but possible Very unlikely to occur Almost inconceivable that the event will occur Value 5 4 3 2 1 12 V10 January 2014 Example Risk Tolerability Matrix (current risk matrix managed by the Safety Committee) Risk Probability Frequent 5 Occasional 4 Remote 3 Improbable 2 Extremely Improbable 1 Catastrophic 5 Unacceptable Unacceptable Unacceptable Review Review Risk Severity Very Damaging 4 Serious 3 Unacceptable Unacceptabl e Unacceptable Review Review Review Review Review Acceptable Acceptable Of Concern 2 Review Review Review Acceptable Acceptable Minor 1 Review Review Acceptable Acceptable Acceptable UNACCEPTABLE: The risk is unacceptable and major mitigation measures are required to reduce the level of risk to as low as reasonably practicable. REVIEW: The level of risk is such that mitigation measures may be required to reduce the level of risk as low as reasonably practicable. Where further risk reduction/mitigation is not practical or viable, the risk may be accepted, provided that the risk is understood and has the endorsement of the Safety Committee. ACCEPTABLE: Risk is considered acceptable but should be reviewed if it recurs. 6.5 Risk Management Process The risk management process is illustrated below. Risk mitigation could take a number of forms. Change to procedure, change to BGA requirements and safety education are potentially simple and quick solutions. However, it is highly likely that significant risks may require focussed project work to ensure a sustainable measured reduction in risk. 13 V10 January 2014 The Risk Management Process Safety Analysis and Safety Committee identifies risk Safety Committee reviews risk Risk accepted? BGA Accident & Incident Reporting System Club Level Incident Reporting System Club reviews reports and identifies significant risks Yes? Record* No Establish risk mitigation via the responsible post holder with the support of the BGA Operations Group Safety Committee reviews risk Risk controlled? Is the significant risk accepted as a local issue to be mitigated locally? No Yes. Establish mitigation through local process and record action. Yes? Record fact* No *Where records are made, the detail will be referenced in Safety Committee meeting notes. 14 V10 January 2014 7. Safety Assurance 7.1 Safety Assurance through Compliance Management Safety assurance is established through compliance management. The BGA airworthiness and training activities are subject to compliance management processes that are independent from BGA airworthiness and training processes and post holders. Feedback from the airworthiness and training activities performance and findings are presented to the Accountable Manager at least annually. Wider safety assurance ie beyond airworthiness and training is met through the routine activity of the Safety and other Committees under their Terms of Reference. 7.2 Compliance Management Process & Procedures The BGA Airworthiness Exposition and the BGA Training Organisation and Operations Manual describe the compliance management process and procedures required to satisfy the oversight of BGA, CAA and EASA requirements. The compliance management processes are also designed to support and assist CAA surveillance of the BGA Airworthiness and Training Organisation approvals. 7.3 The Compliance Management Process - Schematic Compliance Manager Audit Cycle monitors compliance Audit plan, activity and findings Control failed or safety issue Rectification 15 V10 January 2014 8. Change Management Process 8.1 Change Hazard and Risk Assessment Changes in process likely to impact on BGA airworthiness and training should be subject to hazard and risk assessment by the Safety Committee. A structured approach will be used as described in 6.4 above. 16 V10 January 2014 9. Emergency Response Planning 9.1 Emergency Response Plan An emergency response plan should be established by all BGA sites that describe the actions to be taken in the event of an emergency related to flying operations. This does not include emergencies not related to flying operations, for example those directly associated with buildings (Health & Safety, fire, etc) and road traffic (accidents) which are subject to other response requirements. The emergency response plan should be accessible during flying operations and should describe;  How the flying operation will transition from normal to emergency operations  Who will take charge of the emergency  How efforts to resolve the emergency will be co-ordinated  How operations will continue or return to normal after the emergency  How the emergency response plan will be co-ordinated with other organisations, for example the emergency services  Frequency of review and who is responsible 9.2 Guidance Material The BGA-published ‘post-accident guide’ includes suitable information and templates. Refer to the BGA website. 17 V10 January 2014 10. Communication The promotion of safety and quality within the BGA is a responsibility of the Accountable Manager. Internal and external communication tools will be used to ensure relevant and timely safety education & promotion. 10.1 Communication of Safety Concerns Communication is vital in matters of safety. Procedures are in place to ensure that any significant safety concerns can be reported within the organisation for resolution (refer to 6.1). It is essential that all significant safety concerns or suggestions are responded to by the safety organisation. 10.2 Safety Education Communication The BGA shall maintain and develop its safety communication such that it;  Ensures that clubs are properly consulted and informed on safety related matters  Ensures that all key post holders throughout the BGA are aware of BGA SMS  Conveys safety-critical information, especially that related to assessed risks and hazards  Explains why particular actions are taken  Explains why changes are introduced Regular dialogue will take place between the Safety Committee and the Communications Officer. 18 V10 January 2014 APPENDIX 1 – EXAMPLE CLUB SAFETY REVIEW CONTENT Name of Club: Name(s) of Person(s) carrying out the Club Safety Review: Date of Club Safety Review: Club Management Structure Is the club supervisory structure, as it relates to safety policy, practices and procedures, clearly defined and available to members? Has the club a nominated safety officer? Does he report to the Chairman? Does the club have a programme to evaluate hazards and promote safety in accordance with BGA SMS requirements? Are there an adequate number of active and current instructors, and a CFI succession plan? Information for Pilots Are flying orders, local flying rules and letters of agreement readily available to members? Are glider and other club aircraft manuals and BGA manuals readily available to members? Where is safety information on display? Are local and regional air maps available? Are current NOTAMs and Met reports available? How are pilots briefed before flying commences? Aircraft Are all club gliders equipped with energy absorbing cushions? Are energy absorbing cushions encouraged in private gliders? Are glider ballast weights readily available for club gliders? How are they secured in the aircraft? Are all club gliders provided with audio varios? Winches and other Vehicles Who is responsible for the maintenance of the equipment in efficient working order? Are winch cables and cable assemblies fit for purpose, used with appropriate weak links and routinely inspected? Are appropriate ground warning signs provided? 19 V10 January 2014 How do people on the airfield know that a winch launch is underway e.g. is there a beacon on the winch? Airfield How is access controlled? What safeguards are in place to avoid conflict with other airfield users? What public rights of way exist on the airfield? What safeguards are in place to protect the public? What obstacles or hazards, including rough ground, (temporary or permanent) exist on the airfield? How are these marked? Pilots How is pre-solo training recorded to meet BGA ATO requirements? Has the club a post-licence development training programme? Are visiting pilots given a site briefing? Are members required to seek CFI approval for ownership of a new type? Is aircraft conversion advice provided for new owners? Operations What supervision is provided at the launch point? What circuit procedures are employed for both gliders and powered aircraft? What R/T procedures are employed? Are aerotow ropes and assemblies fit for the purpose, used with appropriate weak links, and inspected before use? Visitors Is there a recognised system for receiving and dealing with visitors? Are there signs at the airfield entrance guiding visitors safely to a reception area? Who is responsible for supervising visitors and briefing them regarding appropriate behaviour on the airfield? Emergencies Is the club disaster/accident plan up to date and readily available to club members at both the launch point and at the clubhouse? Is the emergency equipment checked? 20 V10 January 2014 How often and by whom? Do the emergency services know how to get to the airfield? Has the club a list of members who are first-aid trained displayed at the launch point and in the clubhouse? Is a check carried out at the end of flying to ensure that all aircraft are accounted for? Follow up Actions (if required) Review Findings 21 V10 January 2014 APPENDIX 2 – GUIDANCE ON CLUB LEVEL INCIDENT REPORTING All accidents resulting from the flying operations of BGA gliding clubs must be reported to the BGA. These include those reported to the AAIB, flying accidents resulting in minor injury and/or minor damage, and accidents unconnected with flight, for example encounters with moving winch cables, towed gliders hitting an object, glider damage from livestock or wind. An INCIDENT is an unusual event which takes place in connection with the aviation activities of the club, but with no injury to persons and no damage to aircraft or property. All serious incidents and all incidents with safety implications beyond the originating club should be reported to the BGA. All other incidents should be documented locally and managed by the club. As such, clubs are to establish a club incident reporting system that proactively encourages reporting. Incident reporting to the BGA Examples of incidents that should be reported to the BGA are indicated below: Preparation for flight Technical Launch failures In flight On ground Examples Rigging errors; glider incorrectly configured for flight An aircraft component broke or did not operate correctly Unusual failures; for instance glider on winch launch hits its own cable, frequent cable/launch equipment failures, tug upset Inadvertent stall/spin, near collision with glider or tug, undershot airfield, uncontrolled or heavy landing, exceeded VNE, airbrake/undercarriage control confusion, lost above cloud, unusual weather/canopy misting, death from natural causes in a 2-seat glider Winch cable dropping outside the airfield Club Incident reporting Examples of incidents best handled by the club are indicated below: Inadequate DI Potential collision taking off or landing Hazardous circuit or approach Poor handling Ground-loop without damage Poor parking/ ground collision risk Hangar rash Pedestrians on the airfield Out of date or incomplete paperwork Airmanship issues 22 V10 January 2014 Example Club Incident Reporting Form A very simple form can suffice for club incident reporting. The important activities are to document the incident, to regularly review reported incidents, and to document any action taken, as indicated below: MUCH SOARING GC - INCIDENT REPORTING Club members are encouraged to report any incident that they believe had a safety implication. Date Event Reported by Follow up actions 28/4/14 Approaching long on runway 25 after final glide, I encountered heavy sink and nearly undershot . A Bloggs Noted – A Hero, CFI 16/5/14 It was blowing 25kts and I found most of the club gliders at the launch point weren’t parked properly. D Jones (K8 pilot) Noted. For next instructors meeting- A Hero, CFI 17/5/14 A K13 experienced a winch launch failure because the winch ran out of fuel. Landed safely. F Smith (Duty Instructor) Third occurrence of this type this year. New guidance on refuelling and daily checks now established – A Hero, CFI 18/5/14 During a Puch DI, I noticed that the energy absorbent cushions were missing. Found them in the cable tow out vehicle. Linda Young Noted – B Waire, Safety Officer SHEET NUMBER/YEAR 4 / 14 23